SUBSTANTIATION OF THE EFFECTIVENESS OF A COMPLEX DEWATERING OF SMALL WET MINED ROCK

UDC 622.794:621-1/-9

Authors:

Naduty V.P., D.Sc. (Tech.), Professor,

Sukharyev V.V., Ph.D. (Tech.), Researcher,

Kostyrya S.V., M.S(Tech)

(IGTM NAS of Ukraine)

Abstract. There is a practical analysis of the most commonly used methods of dewatering of wet finely divided mined rock accomplished. Disadvantages of each of them are listed and a complex method based on three methods of dewatering - vibration, electroosmotic and vacuum combined in a single device, was proposed. A scheme of the device and the way it works, as well as the results of dewatering in a combined method on this device are introduced. Equity participation of each method, depending on the dewatering percentage and the length of transportation on this device, is shown. The obtained results of preliminary studies indicate the effectiveness of the proposed complex method of dewatering and on this basis the prospects for widespread use of the method are concluded.

Keywords:

 dewatering, mined rock, vibration, electro-osmosis, vacuum, centrifuge.

References:

1. Gukhman, A.A. (1974), Issledovaniye protsessa teplomassoperenosa [Study of heat and mass transfer processes], Vysshaya shkola, Moscow, SU.

2. Antipov, S.T. (1999), "Kinetics of vacuum drying in a continuous mode", Vestnik Mezhdunarodnoy akademii kholoda,no. 1, pp. 8-12.

3. Deshman, S.N. (1964), Nauchnyye osnovy vakuumnoy tekhniki [Scientific fundamentals of vacuum technology], Mir, Moscow, SU.

4. Lukyanov, I.I. (1975), "Centrifugal filtration", Mekhanizatsiya i elektrifikatsiya selskogo khoziaystva, no. 1, pp. 19-21.

5. Melnik, T.G. and Yablochkov, Z.I. (1979), "Research process and sludge dewatering by centrifugation",  Moskovckiy institute inzhenerov celckokhoziayctvennogo proizvodstva,  pp. 80-82.

6. Naduty, V.P., Yeliseyev, V.I. and Lutsenko, V.I. (2013), "Lifting effect of wet particles in a vertical vibrating tube", Vibratsiyivtekhnitsitatekhnologiyakh, no. 1, pp. 31-36.

7. Naduty, V.P., Lapshin, Ye.S. and Shevchenko, A.I. (2012), "Investigation of the kinetics of dewatering under conditions with vibration screening", Zbahachenniakorysnykhkopalyn[Enrichment of minerals], no. 49, pp. 112-120.

8. Naduty, V.P., Yeliseyev, V.I. and Lutsenko, V.I. (2011), "Influence of vibration on the static position of the meniscus moving in the capillary fluid",VisnykNatsionalnohotekhnichnohouniversytetu "Kharkivskypolitekhnichnyinstytut", no. 59, pp. 104-111.

9. Radushkevich, V.L. and Golberg, G.Yu. (1994), "Intensification of filtration dewatering of coal    flotation waste water using electro-osmosis", Vestnik Instituta obogashcheniya tverdogo topliva, no. 2, pp. 70-76.

10. Naduty, V.P., Sukhariev V.V. and Kostyrya, S.V. M.S. Poljakov Institute of Geotechnical Mechanics under NAS of Ukraine (2014), Prystriy dlia znevodnennia sypkykh materialiv [Device for dewatering of bulk materials], State Register of Patents of Ukraine, Kiev, UA, Pat. № 89501.  

About the authors:

Naduty Vladimir Petrovich, Doctor of Technical Sciences (D.Sc.), Professor, Head of Depart-        ment of Geodynamic Systems and Vibration Technologies, M.S. Polyakov Institute of Geotechnical         Mechanics under the National Academy of Science of Ukraine (IGTM NASU), Dnepropetrovsk, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

Sukharyev Vitaliy Vitalievich, Candidate of Technical Sciences (Ph.D), Researcher in Department of Mechanics of Mineral Processing Machines and Processes, M.C. Polyakov Institute of Geotechnical Mechanics under the National Academy of Science of Ukraine (IGTM NASU), Dnepropetrovsk, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

Kostyrya Sergey Vladimirovich, Master of Science, Engineer in Department of Geodynamic Systems and Vibration Technologies, M.S. Polyakov Institute of Geotechnical Mechanics under the National Academy of Science of Ukraine (IGTM NASU), Dnepropetrovsk, Ukraine, This email address is being protected from spambots. You need JavaScript enabled to view it.

Attachments:
FileDescriptionFile size
Download this file (09.pdf)09.pdfSUBSTANTIATION OF THE EFFECTIVENESS OF A COMPLEX DEWATERING OF SMALL WET MINED ROCK381 kB